PMUF树脂复合硼、硅化物改性杨木的性能

刘强强; 柴宇博; 刘君良; 吕文华

doi:10.19455/j.mcgy.20200201

研究与开发 | 浏览量 : 0 下载量: 85 CSCD: 0

PDF
导出
分享
收藏
专辑

PMUF树脂复合硼、硅化物改性杨木的性能
Properties of Poplar Wood Modified with PMUF Resin and PMUF Compounds
1. 中国林业科学研究院木材工业研究所
2. 中国林业科学研究院林业新技术研究所
2020年34卷第2期页码：1-5
DOI： 10.19455/j.mcgy.20200201

扫描看全文

[1]刘强强,柴宇博,刘君良,吕文华.PMUF树脂复合硼、硅化物改性杨木的性能[J].木材工业,2020,34(02):1-5+9.

LIU Qiang-qiang, CHAI Yu-bo, LIU Jun-liang, et al. Properties of Poplar Wood Modified with PMUF Resin and PMUF Compounds[J]. China Wood Industry, 2020,34(2):1-5.
[1]刘强强,柴宇博,刘君良,吕文华.PMUF树脂复合硼、硅化物改性杨木的性能[J].木材工业,2020,34(02):1-5+9. DOI： 10.19455/j.mcgy.20200201.

LIU Qiang-qiang, CHAI Yu-bo, LIU Jun-liang, et al. Properties of Poplar Wood Modified with PMUF Resin and PMUF Compounds[J]. China Wood Industry, 2020,34(2):1-5. DOI： 10.19455/j.mcgy.20200201.

摘要

采用苯酚-三聚氰胺脲醛（PMUF）树脂及其与硼、硅化物的复合改性剂（PMUF-B、PMUF-Si）浸渍处理人工林杨木。结果表明:与未处理材相比,PMUF、PMUF-B及PMUF-Si三种改性材的密度、抗弯性能、硬度均显著提高,吸湿率和吸水率显著降低,抗胀率均在50%以上,冲击韧性略有降低,氧指数均提高1倍以上,甲醛释放量均≤0.3 mg/L,总挥发性有机化合物（TVOC）释放率均≤0.20 mg/（m,2,·h）,耐腐性能显著提高。

Abstract

Samples of poplar wood were respectively impregnated with Phenol-Melamine-UreaFormaldehyde resin（PMUF）, PMUF-boron（PMUF-B） compound and PMUF-silicon（PMUF-Si） compound, which were prepared by the authors at their laboratory. Results showed the density, MOE, MOR, hardness of the samples were increased, meanwhile, moisture absorption rate and water uptake rate were reduced. The anti-swelling efficiency of the modified wood samples was above 50%. The impact toughness of the modified wood samples was slightly decreased. The oxygen index of the modified wood samples was above one time higher than the controlled samples. The formaldehyde emissions of the modified wood samples were lower than 0.3 mg/L. The total volatile organic compounds of the modified wood samples were lower than 0.20 mg/（m,2,·h）. The decay resistance of the modified wood samples was significantly improved.