Analytical Method for Kresoxim-Methyl by HPLC and Leaching Performance of Treated Wood

ZHANG Jingpeng; ZHANG Qingshuo; JIANG Mingliang; WU Yuzhang

doi:10.12326/j.2096-9694.2022135

RESEARCH PAPERS | Views : 0 下载量: 24 CSCD: 0

PDF
Export
Share
Collection
Album

Analytical Method for Kresoxim-Methyl by HPLC and Leaching Performance of Treated Wood
1.Research Institute of Wood Industry，Chinese Academy of Forestry，Beijing 100091，China
Vol. 37, Issue 2, Pages: 66-71(2023)
DOI： 10.12326/j.2096-9694.2022135

扫描看全文

张景朋,张卿硕,蒋明亮等.醚菌酯高效液相色谱分析方法及其防腐材抗流失性能研究[J].木材科学与技术,2023,37(02):66-71.

ZHANG Jingpeng,ZHANG Qingshuo,JIANG Mingliang,et al.Analytical Method for Kresoxim-Methyl by HPLC and Leaching Performance of Treated Wood[J].Chinese Journal of Wood Science and Technology,2023,37(02):66-71.
张景朋,张卿硕,蒋明亮等.醚菌酯高效液相色谱分析方法及其防腐材抗流失性能研究[J].木材科学与技术,2023,37(02):66-71. DOI： 10.12326/j.2096-9694.2022135.

ZHANG Jingpeng,ZHANG Qingshuo,JIANG Mingliang,et al.Analytical Method for Kresoxim-Methyl by HPLC and Leaching Performance of Treated Wood[J].Chinese Journal of Wood Science and Technology,2023,37(02):66-71. DOI： 10.12326/j.2096-9694.2022135.

摘要

采用紫外检测器及C18反相色谱柱，优化得到分析醚菌酯的色谱条件：,V,（甲醇）∶,V,（水）=85∶15为流动相，流速0.8 mL/min，检测波长220 nm。醚菌酯的质量浓度在5~100 mg/L范围内时，标准曲线决定系数为0.9997，线性相关性显著；分析样品的变异系数为0.55%，样品的回收率为99.6%~101.5%。抗流失试验结果表明：醚菌酯防腐工作液的质量分数为0.04%、0.08%和0.16%时，马尾松（,Pinus massoniana,）和杉木（,Cunninghamia lanceolata,）处理材的流失率分别在4.7%~7.5%和3.2%~6.9%之间，低于107杨（,Populus,×,euramericana, cv.‘74/76’）处理材（11.5%~18.4%）。3种处理材的流失率均在20%以下，抗流失性较好。乙醇溶解醚菌酯处理材的流失率稍高于水基化制剂处理材的流失率，因此将醚菌酯制备成水基化制剂可用于户外处理木材及其制品。

Abstract

UV detector and C18 reversed-phase column were used for detection. The chromatographic conditions for analysis of kresoxim-methyl were as follows: flow phase methanol-water ratio of 85∶15, the flow rate of 0.8 mL/min, UV detection wavelength of 220 nm. There was a good linear relationship between kresoxim-methyl concentration and chromatographic peak area in the range of 5~100 mg/L, with a determination coefficient of 0.9997. The coefficient of variation and recovery of samples were 0.55% and 99.6%~101.5%, respectively. The results of the leaching test showed that when the concentrations were 0.04%, 0.08%, and 0.16%, the leaching rate of kresoxim-methyl from Masson pine and Chinese fir were 4.7%~7.5% and 3.2%~6.9%, which were significantly lower than those of treated poplar‘107’(11.5%~18.4%). The leaching rate of kresoxim-methyl in the treated Masson pine, Chinese fir and poplar‘107’were all below 20%, the leaching resistance were excellent. The leaching rate of the treated wood with ethanol-dissolved kresoxim-methyl was higher than that of the water-based formulation, therefore the water-based formulation of pyraclostrobin was suitable in outdoor applications of treated wood and wood products.

关键词

醚菌酯高效液相色谱防腐材抗流失性

Keywords

kresoxim-methylhigh performance liquid chromatography(HPLC)treated woodleaching resistance

references

Goodell B, Nicholas D D, Suchultz T P. Wood deterioration and preservation: advances in our changing world[M]. Washington DC: American Chemical Society, 2003.

劳万里, 段新芳, 吕斌, 等. 碳达峰碳中和目标下木材工业的发展路径分析[J]. 木材科学与技术, 2022, 36(1):87-91.

LAO W L, DUAN X F, LYU B, et al. Development path of China wood industry under the targets of carbon dioxide emission peaking and carbon neutrality[J]. Chinese Journal of Wood Science and Technology, 2022, 36(1):87-91.

朱愿. 异噻唑啉酮微乳液型木材防腐体系构建及性能[D]. 北京: 北京林业大学, 2017.

蒋明亮, 李晓文, 马星霞, 等. 丙环唑/戊唑醇处理材的野外耐久性能评价[J]. 木材工业, 2018, 32(6):9-12.

JIANG M L, LI X W, MA X X, et al. Durability of wood treated with preservatives containing propiconazole, tebuconazole and copper by field stake testing in China[J]. China Wood Industry, 2018, 32(6):9-12.

赵培亮. 新型Strobilurins衍生物的设计、合成及生物活性研究[D]. 武汉：华中师范大学, 2008.

Bartlett D W, Clough J M, Godwin J R, et al. The strobilurin fungicides[J]. Pest Management Science, 2002,58(7): 649-662.

张景朋, 蒋明亮, 马星霞, 等. 一种微乳液型木竹材防腐剂及其制备方法: CN112476682B[P]. 2020-12-03.

李金萍. 39%甲硫醚菌酯悬浮剂高效液相色谱分析[J]. 现代农药, 2016, 15(1):22-24.

LI J P. Determination of thiophanate-methyl＋kresoxim-methyl 39% SC by HPLC[J]. Modern Agrochemicals, 2016, 15(1):22-24.

宋天玮, 熊胜, 陈恒辉, 等. 气相色谱法快速检测小麦中醚菌酯和噻呋酰胺的残留[J]. 农药, 2019, 58(4):285-287.

SONG T W, XIONG S, CHEN H H, et al. The detection of kresoxim-methyl and thiafuramide residues in wheat by gas chromatography[J]. Agrochemicals, 2019, 58(4):285-287.

李晓红, 赵传华. 40%醚菌酯·苯醚甲环唑可湿性粉剂高效液相色谱分析[J]. 广东化工, 2011, 38(3):136-137.

LI X H, ZHAO C H. Analysis of kresoxim-methyl and difenoconazole in 40% WP by HPLC[J]. Guangdong Chemical Industry, 2011, 38(3):136-137.

刘一星, 赵广杰. 木材学[M]. 北京: 中国林业出版社, 2012.

席丽霞, 蒋明亮. 高效液相色谱测定多菌灵及三唑处理材的流失性能[J]. 木材工业, 2013, 27(1):54-57.

XI L X, JIANG M L. Carbendazim and triazole leachability evaluation in treated wood[J]. China Wood Industry, 2013, 27(1):54-57.

李晓文, 席丽霞, 蒋明亮. 5种三唑微乳液及其铜胺制剂的抗流失性能[J]. 林业科学, 2017, 53(3): 147-153.

LI X W, XI L X, JIANG M L. The leachability of five kinds of triazoles and their copper triazole formulations[J]. Scientia Silvae Sinicae, 2017, 53(3): 147-153.

ZHANG J, Kamdem D P. FTIR characterization of copper ethanolamine-wood interaction for wood preservation[J]. Holzforschung, 2000, 54(2):119-122.

Kartal S N, Brischke C, Rapp A O, et al. Biological effectiveness of didecyl dimethyl ammonium tetrafluoroborate (DBF) against basidiomycetes following preconditioning in soil bed tests[J]. Wood Science and Technology, 2006, 40(1):63-71.

Alert me when the article has been cited

提交

暂无数据